PDF下載
[1]孟鑫,陈伟,陈柏校.蕭山4 000 t/d汙泥集中焚燒處理項目實踐[J].中國給水排水,2022,38(8):127-132.
MENGXin,CHENWei,CHENBai-xiao.Practice of Xiaoshan 4 000 t/d Centralized Sludge Incineration Project[J].China Water & Wastewater,2022,38(8):127-132.點擊複制
蕭山4 000 t/d汙泥集中焚燒處理項目實踐
中國給水排水[ISSN:1000-4062/CN:12-1073/TU] 卷: 第38卷 期數: 2022年第8期 頁碼: 127-132 欄目: 出版日期: 2022-04-17
Title:Practice of Xiaoshan 4 000 t/d Centralized Sludge Incineration Project
作者:孟鑫1， 陳偉2， 陳柏校3（1.杭州蕭山環境投資發展有限公司，浙江 杭州 311200；2.杭州藍成環保能源有限公司，浙江 杭州 311200；3.杭州国泰环保科技股份有限公司，浙江 杭州 311200）
Author(s):MENG Xin1， CHEN Wei2， CHEN Bai-xiao3（1. Hangzhou Xiaoshan Environmental Investment Development Co. Ltd.， Hangzhou 311200， China； 2. Hangzhou Lancheng Environmental Protection Energy Co. Ltd.， Hangzhou 311200， China； 3. Hangzhou Guotai Environmental Protection Technology Co. Ltd.， Hangzhou 311200， China）
關鍵詞:汙泥焚燒; 深度脱水; 循环流化床锅炉
Keywords:municipal sludge incineration; deep dewatering of sludge; circulating fluidized bed boiler
摘要:蕭山4 000 t/d污泥集中焚烧处理项目针对污水厂污泥处理难题，通过深度脱水与焚烧发电相结合的方式处理污泥。深度脱水工艺采用化学调理和机械压滤的脱水方式，不同含水率的污泥通过一次压滤脱水就能达到焚烧要求。脱水干化后的污泥含水率降至45%~50%，与质量比为10%的煤混合后，送入循环流化床锅炉进行焚烧。与普通燃煤电厂掺烧污泥相比，本项目泥煤配比有重大突破，汙泥焚燒量有很大的提高，入炉焚烧处理污泥达1 800 t/d（含水率45%）。污泥燃烧的余热用于发电，实现了污泥能量转化和净能量输出。烟气处理系统配置石灰石-石膏湿法脱硫、静电除尘、布袋除尘、低氮燃烧等技术措施，烟气排放指标长期稳定优于欧盟2010排放标准。
Abstract:In view of the difficult issues of sludge treatment in a wastewater treatment plant, Xiaoshan 4 000 t/d centralized sludge was treated by the combination of deep dewatering, incineration and power generation. Chemical conditioning and mechanical pressure filtration are adopted in the process of deep dewatering, and the sludge with various moistures can be dewatered to meet the requirement of incineration by the single dewatering process. After dewatering, the sludge moisture was reduced to 45%-50%. After mixing with coal of 10% weight, the sludge was sent to the circulating fluidized bed boiler for incineration. Compared with common coal-fueled power plants, the sludge-to-coal ratio is much higher, thus the sludge incineration capacity has been greatly improved as high as 1 800 t of sludge (moisture 45%) every day. The waste heat of sludge combustion is used for power generation, thus realizing energy conversion and net energy output. The flue gas treatment system is equipped with limestone-gypsum wet desulfurization, electrostatic dust removal, baghouse dust removal, low nitrogen combustion, and other technical measures, thus the gas emission stably outperforms the Directive of EU2010/75/EC in a long run.
相似文獻/References:
[1]郝曉地,于文波,時琛,等.汙泥焚燒灰分磷回收潛力分析及其市場前景[J].中國給水排水,2021,37(4):5.
HAO Xiao-di,YU Wen-bo,SHI Chen,et al.Potential Analysis and Market Prospects of Phosphorus Recovery from the Bottom Ashes of Sludge Incineration[J].China Water & Wastewater,2021,37(8):5.
[2]應基光,林莉峰,邵欽.基于鼓泡流化床的汙泥焚燒保護控制[J].中國給水排水,2021,37(10):133.
YING Ji-guang,LIN Li-feng,SHAO Qin.Protection Control of Sludge Incineration Based on Bubbling Fluidized Bed[J].China Water & Wastewater,2021,37(8):133.
[3]楊漢文,王建國,李沖,等.市政汙泥幹化焚燒技術應用工程案例[J].中國給水排水,2021,37(12):136.
YANG Han-wen,WANG Jian-guo,LI Chong,et al.Application Project of Municipal Sludge Drying and Incineration Technology[J].China Water & Wastewater,2021,37(8):136.
[4]趙林輝,林莉峰,朱運濤.大型汙泥焚燒項目的汙泥脫水運行優化研究[J].中國給水排水,2021,37(12):145.
ZHAO Lin-hui,LIN Li-feng,ZHU Yun-tao.Study on Operation Optimization of Sludge Dewatering in Large Scale Sludge Incineration Project[J].China Water & Wastewater,2021,37(8):145.
[5]段妮娜,譚學軍,張辰.汙水處理廠汙泥獨立焚燒的熱力計算方法解析[J].中國給水排水,2021,37(16):83.
DUAN Ni-na,TAN Xue-jun,ZHANG Chen.Analysis of Sewage Sludge Mono-incineration Thermodynamic Calculation Method in a Sewage Treatment Plant[J].China Water & Wastewater,2021,37(8):83.
[6]應基光,林莉峰,王麗花.白龍港汙泥二期煙氣在線監測系統設計與調試[J].中國給水排水,2022,38(6):117.
YINGJi-guang,LIN Li-feng,WANG Li-hua.Design and Commissioning of CEMS for Bailonggang Phase Ⅱ Sludge Project[J].China Water & Wastewater,2022,38(8):117.
[7]朱運濤,林莉峰,趙林輝.汙泥流化床焚燒煙氣汙染物排放特性研究[J].中國給水排水,2022,38(11):115.
ZHUYun-tao,LINLi-feng,ZHAOLin-hui.Emission Characteristics of Pollutants in Flue Gas from Sludge Fluidized Bed Incineration Process[J].China Water & Wastewater,2022,38(8):115.
[8]汪芸芸,李夢瓊,林莉峰.鼓泡流化床汙泥焚燒爐焚燒控制技術研究[J].中國給水排水,2022,38(18):42.
WANGYun-yun,LI Meng-qiong,LINLi-feng.Study on Incineration Control Technology of Sludge Bubbling Fluidized Bed Incinerator[J].China Water & Wastewater,2022,38(8):42.
[9]宋世琨,楊巍,劉波,等.市政汙泥獨立焚燒項目煙氣處理工藝設計[J].中國給水排水,2024,40(8):70.
SONGShi-kun,YANGWei,LIUBo,et al.Design of Flue Gas Treatment Technology for Municipal Sludge Independent Incineration Project[J].China Water & Wastewater,2024,40(8):70.
[10]安葉,周彥靈,潘曉玥,等.“雙碳”背景下低碳汙泥處理處置技術路線優化探索[J].中國給水排水,2024,40(20):23.
ANYe,ZHOUYan-ling,PANXiao-yue,et al.Exploration on Optimizing the Technical Route of Low-carbon Sludge Treatment and Disposal under the Background of “Carbon Peak and Carbon Neutralization”[J].China Water & Wastewater,2024,40(8):23.
更新日期/Last Update: 2022-04-17
中國給水排水杂志社官方网所有资料均源于网上的共享资源及期刊共享，请特别注意勿做其他非法用途 如有侵犯您的版权或其他有损您利益的行为，请联系指出，本网会立即进行改正或删除有关内容
論文發表投稿郵箱：cnwater@vip.163.com
CopyRight (C)2016 中國給水排水杂志社官方网 版权所有 津ICP備20004590號
- 首 页
- 期刊介紹
- 編委會
- 投稿須知
- 文章查詢
- 學術會議
- 廣告合作
- 發行訂閱
- 在線留言
- English
上一篇下一篇
PDF下載
[1]孟鑫,陈伟,陈柏校.蕭山4 000 t/d汙泥集中焚燒處理項目實踐[J].中國給水排水,2022,38(8):127-132.
MENGXin,CHENWei,CHENBai-xiao.Practice of Xiaoshan 4 000 t/d Centralized Sludge Incineration Project[J].China Water & Wastewater,2022,38(8):127-132.
點擊複制
蕭山4 000 t/d汙泥集中焚燒處理項目實踐
中國給水排水[ISSN:1000-4062/CN:12-1073/TU] 卷: 第38卷 期數: 2022年第8期 頁碼: 127-132 欄目: 出版日期: 2022-04-17
- Title:
- Practice of Xiaoshan 4 000 t/d Centralized Sludge Incineration Project
- 作者:
- 孟鑫1， 陈伟2， 陈柏校3
- （1.杭州萧山环境投资发展有限公司，浙江 杭州 311200；2.杭州藍成環保能源有限公司，浙江 杭州 311200；3.杭州国泰环保科技股份有限公司，浙江 杭州 311200）
- Author(s):
- MENG Xin1， CHEN Wei2， CHEN Bai-xiao3
- （1. Hangzhou Xiaoshan Environmental Investment Development Co. Ltd.， Hangzhou 311200， China； 2. Hangzhou Lancheng Environmental Protection Energy Co. Ltd.， Hangzhou 311200， China； 3. Hangzhou Guotai Environmental Protection Technology Co. Ltd.， Hangzhou 311200， China）
- 關鍵詞:
- 汙泥焚燒; 深度脫水; 循環流化床鍋爐
- Keywords:
- municipal sludge incineration; deep dewatering of sludge; circulating fluidized bed boiler
- 摘要:
- 蕭山4 000 t/d污泥集中焚烧处理项目针对污水厂污泥处理难题，通过深度脱水与焚烧发电相结合的方式处理污泥。深度脱水工艺采用化学调理和机械压滤的脱水方式，不同含水率的污泥通过一次压滤脱水就能达到焚烧要求。脱水干化后的污泥含水率降至45%~50%，与质量比为10%的煤混合后，送入循环流化床锅炉进行焚烧。与普通燃煤电厂掺烧污泥相比，本项目泥煤配比有重大突破，汙泥焚燒量有很大的提高，入炉焚烧处理污泥达1 800 t/d（含水率45%）。污泥燃烧的余热用于发电，实现了污泥能量转化和净能量输出。烟气处理系统配置石灰石-石膏湿法脱硫、静电除尘、布袋除尘、低氮燃烧等技术措施，烟气排放指标长期稳定优于欧盟2010排放标准。
- Abstract:
- In view of the difficult issues of sludge treatment in a wastewater treatment plant, Xiaoshan 4 000 t/d centralized sludge was treated by the combination of deep dewatering, incineration and power generation. Chemical conditioning and mechanical pressure filtration are adopted in the process of deep dewatering, and the sludge with various moistures can be dewatered to meet the requirement of incineration by the single dewatering process. After dewatering, the sludge moisture was reduced to 45%-50%. After mixing with coal of 10% weight, the sludge was sent to the circulating fluidized bed boiler for incineration. Compared with common coal-fueled power plants, the sludge-to-coal ratio is much higher, thus the sludge incineration capacity has been greatly improved as high as 1 800 t of sludge (moisture 45%) every day. The waste heat of sludge combustion is used for power generation, thus realizing energy conversion and net energy output. The flue gas treatment system is equipped with limestone-gypsum wet desulfurization, electrostatic dust removal, baghouse dust removal, low nitrogen combustion, and other technical measures, thus the gas emission stably outperforms the Directive of EU2010/75/EC in a long run.
相似文獻/References:
[1]郝曉地,于文波,時琛,等.汙泥焚燒灰分磷回收潜力分析及其市场前景[J].中國給水排水,2021,37(4):5.
HAO Xiao-di,YU Wen-bo,SHI Chen,et al.Potential Analysis and Market Prospects of Phosphorus Recovery from the Bottom Ashes of Sludge Incineration[J].China Water & Wastewater,2021,37(8):5.
[2]應基光,林莉峰,邵欽.基于鼓泡流化床的汙泥焚燒保护控制[J].中國給水排水,2021,37(10):133.
YING Ji-guang,LIN Li-feng,SHAO Qin.Protection Control of Sludge Incineration Based on Bubbling Fluidized Bed[J].China Water & Wastewater,2021,37(8):133.
[3]楊漢文,王建國,李沖,等.市政汙泥幹化焚燒技術應用工程案例[J].中國給水排水,2021,37(12):136.
YANG Han-wen,WANG Jian-guo,LI Chong,et al.Application Project of Municipal Sludge Drying and Incineration Technology[J].China Water & Wastewater,2021,37(8):136.
[4]趙林輝,林莉峰,朱運濤.大型汙泥焚燒项目的污泥脱水运行优化研究[J].中國給水排水,2021,37(12):145.
ZHAO Lin-hui,LIN Li-feng,ZHU Yun-tao.Study on Operation Optimization of Sludge Dewatering in Large Scale Sludge Incineration Project[J].China Water & Wastewater,2021,37(8):145.
[5]段妮娜,譚學軍,張辰.汙水處理廠汙泥獨立焚燒的熱力計算方法解析[J].中國給水排水,2021,37(16):83.
DUAN Ni-na,TAN Xue-jun,ZHANG Chen.Analysis of Sewage Sludge Mono-incineration Thermodynamic Calculation Method in a Sewage Treatment Plant[J].China Water & Wastewater,2021,37(8):83.
[6]應基光,林莉峰,王麗花.白龍港汙泥二期煙氣在線監測系統設計與調試[J].中國給水排水,2022,38(6):117.
YINGJi-guang,LIN Li-feng,WANG Li-hua.Design and Commissioning of CEMS for Bailonggang Phase Ⅱ Sludge Project[J].China Water & Wastewater,2022,38(8):117.
[7]朱運濤,林莉峰,趙林輝.汙泥流化床焚燒煙氣汙染物排放特性研究[J].中國給水排水,2022,38(11):115.
ZHUYun-tao,LINLi-feng,ZHAOLin-hui.Emission Characteristics of Pollutants in Flue Gas from Sludge Fluidized Bed Incineration Process[J].China Water & Wastewater,2022,38(8):115.
[8]汪芸芸,李夢瓊,林莉峰.鼓泡流化床汙泥焚燒炉焚烧控制技术研究[J].中國給水排水,2022,38(18):42.
WANGYun-yun,LI Meng-qiong,LINLi-feng.Study on Incineration Control Technology of Sludge Bubbling Fluidized Bed Incinerator[J].China Water & Wastewater,2022,38(8):42.
[9]宋世琨,楊巍,劉波,等.市政汙泥獨立焚燒項目煙氣處理工藝設計[J].中國給水排水,2024,40(8):70.
SONGShi-kun,YANGWei,LIUBo,et al.Design of Flue Gas Treatment Technology for Municipal Sludge Independent Incineration Project[J].China Water & Wastewater,2024,40(8):70.
[10]安葉,周彥靈,潘曉玥,等.“雙碳”背景下低碳汙泥處理處置技術路線優化探索[J].中國給水排水,2024,40(20):23.
ANYe,ZHOUYan-ling,PANXiao-yue,et al.Exploration on Optimizing the Technical Route of Low-carbon Sludge Treatment and Disposal under the Background of “Carbon Peak and Carbon Neutralization”[J].China Water & Wastewater,2024,40(8):23.
更新日期/Last Update: 2022-04-17
